Ford 3.5 EcoBoost Engine Problems
Ford Ecoboost 3.5 by Numobeer - CC-BY-SA-4.0
Ford’s EcoBoost line of engines has become synonymous with the effective combination of power and fuel efficiency. The 3.5L V-6 variant lives at the lineup’s center and offers prodigious power to everything from the Fusion sedans to F-150 trucks. In general, the 3.5L Ecoboost continues to grow its fan base due to its strength and durability. Still, some issues remain common on a few variants of this engine.
This article will dig into the common Ford 3.5 EcoBoost engine problems and detail the issues and how much it will cost to repair them.
TRENDING
If you’re considering buying a used 2008 Ford Edge, here’s what owners have to say about the most common 2008 Ford Edge problems.
The Most Common Ford 3.5L EcoBoost Problems:
- Intercooler Condensation. Cost to fix: $500
- Timing Chain Wear. Cost to fix: $2000
- Ignition Issues. Cost to fix: $241-$284.
- Carbon Buildup. Cost to fix: $400-600
Intercooler Condensation
Problem:
In high humidity conditions, some models of F-150 have issues with water being trapped (vs. vaporized) in the intercooler. This is due to a design flaw that does not allow water to be quickly evaporated in high humidity conditions. This can cause stumbling or hesitation under high boost loads or highway speeds. Ford redesigned this part in later years to avoid the issue.
Cost:
The aftermarket offers a solution for this problem via an apparatus called a “catch can.” Essentially, these devices use the vacuum created by the turbos to catch oily water vapor from the intercooler. These rigs run from $200 to $400 and can easily be installed by a mechanic for around $150.
TRENDING
Shopping for a 2016 Ford Explorer? Here are the most common problems with used 2016 Explorers as reported by owners, and how to avoid buying a faulty used model.
Timing Chain Wear
Problem:
Since the Ecoboost is a turbocharged engine, it is even more imperative to maintain due to the stress that the oil is consistently under. If maintenance is not kept up, the timing chain can wear out prematurely, along with the chain tensioner and pulleys. Once this happens, the engine will fall out of timing alignment and experience many issues.
Cost:
Unfortunately, this is an expensive repair as it requires a good bit of engine teardown to accomplish the task of replacing the timing chain parts and pieces—figure north of $2,000 for this intensive job.
Ignition System Issues
Problem:
The 3.5L Ecoboost was apparently prone to ignition issues that come from the spark plug. It’s such a prevalent and disruptive issue that drivers will quickly notice. The engine assemblage comes with a direct fuel injection system that works with a twin-turbo system. Although the turbo system can provide sufficient power to the combustion system, it can potentially overload the ignition system.
As time goes on, wear and tear will affect the spark plugs and ignition coils. While this is a reasonably simple fix by replacing the spark plugs, this issue will cause more severe problems to your Ecoboost engine. Some of the most common symptoms of this issue are:
- Shuttering
- Engine misfires
- Illuminating check engine light
Cost:
Thankfully, the ignition system issue of the 3.5L Ecoboost doesn’t require significant repair. As mentioned, the primary fix is to replace the worn-out parts. In this case, it’s the Ecoboost engine’s spark plugs. The spark plug part is about $75, and you can go the DIY route for the installation. However, if you go to a mechanic, expect to pay between $241 and $284.
Carbon Buildup
Problem:
Carbon build is primarily a concern on 1st-gen EcoBoost engines. The first-generation EcoBoost engines only use direct injection, meaning the fuel is sprayed straight into the cylinders. As a result, carbon can accumulate inside the valve intakes. While it’s normal for engines to experience oil blow-by, it’s particularly bad in 1st-gen EcoBoosts since nothing helps clean the ports and valves.
This results in carbon buildup that restricts airflow into the cylinders. While this issue doesn’t strictly require immediate attention, it may lead to drivability issues like power loss, misfires, and rough idling.
Again, this was mainly a concern with first-generation EcoBoost engines. Ford corrected this design flaw with the second-gen 3.5 EcoBoost.
Cost:
The best approach is not to allow the carbon to accumulate so bad that it causes problems. However, once the buildup becomes excessive, an effective fix is to conduct walnut blasting. This solution requires a good-quality shop vac and walnut media shells. Including labor, you may have to pay $400-600+ for this fix. Unless you know what you’re doing, it’s better to let the professionals handle this job.
DOWNLOAD THE APP
The CoPilot app is the smartest way to buy a car. Search all listings in your area, get notified about deals, new listings, and price drops, or chat with one of our copilots for some hands-on advice.
Avoiding the Ford 3.5L Engine Problems
Many of the issues listed on this page can be caught if you are mechanically savvy and know what to listen for when test driving a vehicle equipped with this engine. For the rest of us, get a pre-purchase inspection from a local mechanic.
Most mechanics offer inspections for vehicles that include a complete visual examination and full diagnostic. That pesky timing chain or misfiring cylinder might be missed during a test drive but will be found during a pre-purchase inspection.
Get a Curated List of the Best Used Cars Near You
The CoPilot car shopping app is the easiest way to buy a car. Tell us what you’re looking for and we’ll search the inventories of every dealership in your area to make you a personalized list of the best car listings in your area.
Only looking for newer models? CoPilot Compare is the search engine for nearly-new cars. Only see cars 5 years or newer with low mileage - CoPilot Compare is the best way to find off-lease, early trade-in, and CPO cars.
The best part? CoPilot is built using the same technology that dealerships use to buy and sell their inventories, so we have more info on each vehicle than competitors. CoPilot doesn’t work with dealerships, so there are no sponsored posts or other shady practices - just the most info on the best cars. Check out our About Us page to see how CoPilot works.
